Suzuki ATV Forum banner

1 - 3 of 3 Posts

·
Registered
Joined
·
2 Posts
Discussion Starter #1
like everyone else , carb problems. quad has sat for 4 years went to start , it only runs with choke on....backfires if you try to rev up. fuel shut off seems good did a vacuum test works good
.looked for leaks in between carb and motor. looks good, took carb off and cleaned everything inside blew out with air. there's one jet in there that goes in front of butterfly it is backed out about 3 and ahalf turns. not sure about that one. that is the only one I didn't take out and clean. quad only has 1100 km on it. stumped maybe a carb kit not sure
 

·
Super Moderator
Joined
·
7,717 Posts
Just cleaning the carb in most instances isn’t good enough. A good cleaning along with a carb rebuild kit would be my suggestion.


Sent from my iPhone using Tapatalk
 

·
Registered
Joined
·
2 Posts
Discussion Starter #3
got bike running good after I took carb apart a second time , one pluged jet . starts and revs up fine. when driving under a load and you hit the throttle wide open it kind of sputters a little . there was one jet there by butterfly . it was set at 3 and ahalf turns out. could that be to rich??/ or lean ??
 
1 - 3 of 3 Posts
Top