Suzuki ATV Forum banner

Recent content by vdubstreets

  1. New carb adjustment

    Suzuki KingQuad 300
    I replaced the fuel pump and right away noticed pressure coming through so the old pump must of been bad even though I opened it up and it looked OK . After putting it back together it idled on/off choke but only would allow me to give throttle with the choke on. I was able to drive it around...
  2. New carb adjustment

    Suzuki KingQuad 300
    I'll give pressurizing the tank it a try, i did pull fuel through the line to make sure I got it to the fuel filter with a vacuum. It died out in a few seconds because fuel wasn't flowing. I'll just do an oil change, who knows the last time it was done.
  3. New carb adjustment

    Suzuki KingQuad 300
    The previous owner must of modified the petcock because no matter what setting it is gas free flows. I still was not able to get the quad to run using the fuel pump. odds are its all gummed up again even though I rebuilt it not too long ago. with the quad running from another fuel source and a...
  4. New carb adjustment

    Suzuki KingQuad 300
    Assuming the petcock does flow fine, I guess I'll have to dive into the fuel pump not allowing flow. I'll try messing around with the fuel lines and see what I can figure out.
  5. New carb adjustment

    Suzuki KingQuad 300
    Finally some good news! I rebuilt the original carb, adjusted the pilot screw to 2.6 turns from seated and put the airbox back on. I don't have a second nipple off the back of my petcock like some of you say I should (maybe I'm missing a nipple see pics below), and I do have a ON/RES/PRI...
  6. New carb adjustment

    Suzuki KingQuad 300
    it has the ON/PRI/RES but doesn't have any nipples for another vacuum connection. I'll make sure tomorrow but could be crazy.
  7. New carb adjustment

    Suzuki KingQuad 300
    First off, thank you all for your help. This thing has been quite frustrating, I'm usually good with small engines. can anyone confirm? In the image below I have A running to my fuel pump, and B should be capped off (since I dont have a spot on my peacock)? It doesn't show clearly in my manual.
  8. New carb adjustment

    Suzuki KingQuad 300
    So with the criticism of the Chinese Carbs I've decided to go back to the OEM. I rebuilt it a while back but wasn't getting any luck with it. 1. I tested the Peacock by taking off the line flowing into the fuel pump. Gas flows fine. 2. I can see that I'm getting gas into my carb as the fuel...
  9. New carb adjustment

    Suzuki KingQuad 300
    Good point added: 1998/1999 LTF4WDX.
  10. New carb adjustment

    Suzuki KingQuad 300
    Brand new (chinese) carb off amazon. I tried the default adjustment and tried to adjust the idle screw clockwise and counter clockwise 1/4 turn with no changes. Quad will start to run on choke, idle pretty high. If I give any throttle it will bog down. It will run high then the idle will come...
Top